Data sheet
| Hydraulic data | |
|---|---|
| Minimum efficiency index (MEI) | 0.4 |
| Min. fluid temperature Tmin | -20 °C |
| Max. fluid temperature Tmax | 140 °C |
| Max. ambient temperature Tmax | 40 °C |
| Maximum operating pressure PN | 16 bar |
| Note on dimensioning | 16 bar to 120 °C, 13 bar to 140 °C |
| Motor data | |
|---|---|
| Mains connection | 3~400 V, 50 Hz |
| Number of poles | 4 |
| Voltage tolerance | ±10 % |
| Motor efficiency class | IE3 |
| Rated power P2 | 0.37 kW |
| Rated current IN | 1.1 A |
| Rated speed n | 1450 1/min |
| Power factor cos φ100 | 0.66 |
| Motor efficiency 50% ηM 50% | 71.7 % |
| Motor efficiency 75% ηM 75% | 75.8 % |
| Motor efficiency 100% ηM 100% | 77.3 % |
| Insulation class | F |
| Protection class motor | IP55 |
| Motor protection | no |
| Materials | |
|---|---|
| Pump housing | 5.1301/EN-GJL-250 KTL-coated |
| Impeller | Grey cast iron EN-GJL-200 |
| Impeller (optional) | CC480K (G-CuSn10) Bronze Stainless steel 1.4408 |
| Shaft | Stainless steel |
| Mechanical seal | Q7Q7X4GG |
| Lantern | 5.1301/EN-GJL-250 KTL-coated |
| Installation dimensions | |
|---|---|
| Pipe connection, suction side DNs | DN 32 |
| Pipe connection, discharge side DNd | DN 32 |
| Port-to-port length L0 | 320 mm |
Pump curves
Dimensions and dimensions drawings
Atmos GIGA-I 32/150-0,37/4-S1
II pressure measuring connection R1/8" DIN 906; III air vent valve R1/8" DIN EN10226
Wiring diagram
∆: Connection diagram delta connection
Y: Connection diagram star connection
Motor protection switch required on-site. Check the direction of rotation! To change the direction of rotation, exchange any two phases.
| P2≤ 3 kW | 3~400 V Y |
| 3~230 V ∆ | |
| P2≥ 4 kW | 3~690 V Y |
| 3~400 V ∆ |
After removing the bridges, Y-∆ start is possible.
Acoustics
Airborne sound data sheet
| Airborne sound power LW,A | |
|---|---|
| Octave band centre frequency in Hz | Level in dB(A), ref. 20µPa |
| L63 | 10.2 |
| L125 | 25.1 |
| L250 | 31.5 |
| L500 | 36.6 |
| L1000 | 55 |
| L2000 | 47.2 |
| L4000 | 36.4 |
| L8000 | 29.1 |
| Airborne sound-power level (total) Lw | 56 |
| Airborne sound pressure Lp,A,1m | |
|---|---|
| Octave band centre frequency in Hz | Level in dB(A), ref. 1pW |
| L63 | -4.2 |
| L125 | 10.7 |
| L250 | 17.1 |
| L500 | 22.2 |
| L1000 | 40.6 |
| L2000 | 32.8 |
| L4000 | 22 |
| L8000 | 14.7 |
| Airborne sound-pressure level (total) Lp | 41 |
The acoustic values given are based on measurements and in some cases on calculations and may deviate by up to 3 dB.
Ordering information
| Product data | |
|---|---|
| Brand | Wilo |
| Product description | Atmos GIGA-I 32/150-0,37/4-S1 |
| Article number | 2219013 |
| EAN number | 4062679222585 |
| Colour | Green |
| Minimum order quantity | 1 |
| Date of sales availability | 2022-07-01 |
| Packaging | |
|---|---|
| Packaging type | Cardboard box |
| Packaging property | Transport packaging |
| Pieces per pallet | 4 |
| Number per layer | 2 |
| Dimension, weight | |
|---|---|
| Length with packaging | 800 mm |
| Length L | 541 mm |
| Height with packaging | 525 mm |
| Height H | 320 mm |
| Width with packaging | 600 mm |
| Width W | 230 mm |
| Gross weight, approx. m | 52 kg |
| Net weight, approx. m | 46 kg |
Single-stage glanded centrifugal pump with in-line design for pipe installation or installation on a base. Low-oscillation and low-noise close-coupled design with lantern and rigidly connected standard flange motor. With force-flushed, bidirectional bellows mechanical seal (from 37 kW/4-pole, optionally available with a cartridge mechanical seal in back pull-out design for mechanical seal replacement without dismantling the motor) and cavitation-reducing impeller. Flange with R 1/8 pressure measuring connections.
All grey cast iron components are cataphoretic-coated.
Pumps with motors ≥ 5.5 kW are equipped as standard with a PTC thermistor sensor for motor protection.
The motor terminal box ≤ 7.5 kW can be made of metal or plastic. If a metal terminal box is absolutely necessary, please order the appropriate special variant. The motor terminal boxes > 7.5 kW are always made of metal.
- Mechanical seal S1 recommended for water-glycol mixtures with glycol proportions up to max. 50 % by volume and a fluid temperature of -20 °C up to max. +90 °C ... +110 °C and also if there is oil in the water-glycol mixture.
| Operating data | |
|---|---|
| Min. fluid temperature Tmin | -20 °C |
| Max. fluid temperature Tmax | 140 °C |
| Min. ambient temperature Tmin | 0 °C |
| Max. ambient temperature Tmax | 40 °C |
| Maximum operating pressure PN | 16 bar |
| Note on dimensioning | 16 bar to 120 °C, 13 bar to 140 °C |
| Minimum efficiency index (MEI) | 0.4 |
| Motor data | |
|---|---|
| Motor efficiency class | IE3 |
| Mains connection | 3~400 V, 50 Hz |
| Voltage tolerance | ±10 % |
| Rated power P2 | 370 W |
| Rated speed n | 1450 1/min |
| Rated current IN | 1.1 A |
| Power factor cos φ100 | 0.66 |
| Motor efficiency 50% ηM 50% | 71.7 % |
| Motor efficiency 75% ηM 75% | 75.8 % |
| Motor efficiency 100% ηM 100% | 77.3 % |
| Insulation class | F |
| Protection class | IP55 |
| Materials | |
|---|---|
| Pump housing | 5.1301/EN-GJL-250 KTL-coated |
| Impeller | Grey cast iron |
| Shaft | Stainless steel |
| Shaft seal | Q7Q7X4GG |
| Lantern | 5.1301/EN-GJL-250 KTL-coated |
| Installation dimensions | |
|---|---|
| Pipe connection, suction side DNs | DN 32 |
| Pipe connection, discharge side DNd | DN 32 |
| Ordering information | |
|---|---|
| Brand | Wilo |
| Product description | Atmos GIGA-I 32/150-0,37/4-S1 |
| Net weight, approx. m | 46 kg |
| Article number | 2219013 |
Filtered by
Datasheet and documentation
Installation type
Continuous, infinitely variable control, differential pressure-sensitive SC-HVAC system (25) | |||
Antenna GSM/GPRS | |||
D-network dual-band antenna with 3 m cable | 2533862 | ||
D-network tri-band antenna 10 m cable | 2533863 | ||
D-network tri-band antenna 15 m cable | 2533864 | ||
Outdoor temperature sensor Pt 100 | |||
Outdoor temperature sensor Pt 100 | 2533772 | ||
DDG impulse selector | |||
DDG impulse selector | 2533770 | ||
SC communication module BACnet | |||
SC-communication module BACnet MS/TP (slave) | 2538242 | ||
Communication module LON (SC) | |||
Communication module LON (SC) | 2538243 | ||
Pump signalling module | |||
Signalling module pump 1-2 | 2533812 | ||
Signalling module pump 3-6 | 2533836 | ||
SC-HVAC signal board | |||
SC-HVAC signal board | 2119646 | ||
PTC thermistor tripping unit | |||
PTC thermistor tripping unit | 509275993 | ||
Communication module GSM (SC) | |||
Communication module GSM (SC) | 2542216 | ||
SC/SC-FC-HVAC system | |||
SC-HVAC system 1x1,6A-WM (direct starting) | 2545310 | ||
SC-HVAC system 2x1,6A-WM (direct starting) | 2545311 | ||
SC-HVAC system 3x1,6A-WM (direct starting) | 2545312 | ||
SC-HVAC system 4x1,6A-WM (direct starting) | 2545313 | ||
SC-FC-HVAC system 1x1,6A-FC-WM (direct starting) | 2545426 | ||
SC-FC-HVAC system 2x1,6A-FC-WM (direct starting) | 2545427 | ||
SC-FC-HVAC system 3x1,6A-FC-WM (direct starting) | 2545428 | ||
SC-FC-HVAC system 4x1,6A-FC-WM (direct starting) | 2545429 | ||
DDG (4-20mA) | |||
Wilo-DDG 10 Signal Trans.(4-20mA)2G VP. | 2136454 | ||
Wilo-DDG 20 Signal Trans.(4-20mA)2G VP. | 2136456 | ||
Wilo-DDG 40 Signal Trans.(4-20mA)2G VP. | 2136458 | ||
Wilo-DDG 60 Signal Trans.(4-20mA)2G VP. | 2136460 | ||
Wilo-DDG 100 Signal Trans.(4-20mA) | 2211740 | ||
Continuous, infinitely variable control, temperature-dependent SC-HVAC system (19) | |||
Antenna GSM/GPRS | |||
D-network dual-band antenna with 3 m cable | 2533862 | ||
D-network tri-band antenna 10 m cable | 2533863 | ||
D-network tri-band antenna 15 m cable | 2533864 | ||
Outdoor temperature sensor Pt 100 | |||
Outdoor temperature sensor Pt 100 | 2533772 | ||
SC communication module BACnet | |||
SC-communication module BACnet MS/TP (slave) | 2538242 | ||
Communication module LON (SC) | |||
Communication module LON (SC) | 2538243 | ||
Pump signalling module | |||
Signalling module pump 1-2 | 2533812 | ||
Signalling module pump 3-6 | 2533836 | ||
SC-HVAC signal board | |||
SC-HVAC signal board | 2119646 | ||
PTC thermistor tripping unit | |||
PTC thermistor tripping unit | 509275993 | ||
Communication module GSM (SC) | |||
Communication module GSM (SC) | 2542216 | ||
SC/SC-FC-HVAC system | |||
SC-HVAC system 1x1,6A-WM (direct starting) | 2545310 | ||
SC-HVAC system 2x1,6A-WM (direct starting) | 2545311 | ||
SC-HVAC system 3x1,6A-WM (direct starting) | 2545312 | ||
SC-HVAC system 4x1,6A-WM (direct starting) | 2545313 | ||
SC-FC-HVAC system 1x1,6A-FC-WM (direct starting) | 2545426 | ||
SC-FC-HVAC system 2x1,6A-FC-WM (direct starting) | 2545427 | ||
SC-FC-HVAC system 3x1,6A-FC-WM (direct starting) | 2545428 | ||
SC-FC-HVAC system 4x1,6A-FC-WM (direct starting) | 2545429 | ||
Mechanical accessories
Wall fixation/installation on a base (15) | |||
Mounting bracket kit | |||
Mounting bracket F 3-14 SET | 2040968 | ||
Base pump housing | |||
Supporting block pump housing H20 (50/200) | 4213026 | ||
Supporting block pump housing H28 (50/250) | 4213027 | ||
Supporting block pump housing H20 (65/200) | 4213030 | ||
Supporting block pump housing H45 | 4213031 | ||
Supporting block pump housing H80 (80/200) | 4213032 | ||
Supporting block pump housing H55 (100/400 & 150/200) | 4213040 | ||
Supporting block pump housing H55 (50/315) | 4213029 | ||
Supporting block pump housing H55 (100/250) | 4213033 | ||
Supporting block pump housing H30 (100/250 & 100/315) | 4213034 | ||
Supporting block pump housing H80 (80/250 & 100/200) | 4213035 | ||
Supporting block pump housing H110 | 4213036 | ||
Supporting block pump housing H85 (80/315 & 100/315) | 4213038 | ||
Supporting block pump housing H25 (125/400 & 150/400) | 4213039 | ||
KIT pump H20-KTL (Inline 40/200) | 6094815 | ||
Electrical accessories
Pump control (1) | |||
Wilo-EFC | |||
EFC0.37 3x380-480V 50/60Hz IP55 | 2193429 | ||
Pump control/accessories (25) | |||
Sensor card EFC | |||
Sensor Input Card MCB Wilo-EFC | 6084915 | ||
Communication module CC | |||
CC communication module | 2533850 | ||
Connection cable control modules/signalling modules | |||
Control modules connecting cable | 2533790 | ||
Signalling modules connecting cable | 2533890 | ||
BMS base module | |||
BMS base module | 2533800 | ||
Antenna GSM/GPRS | |||
D-network dual-band antenna with 3 m cable | 2533862 | ||
D-network tri-band antenna 10 m cable | 2533863 | ||
D-network tri-band antenna 15 m cable | 2533864 | ||
SMA/FME adapter | 2545548 | ||
Pump signalling module | |||
Signalling module pump 1-2 | 2533812 | ||
Signalling module pump 3-6 | 2533836 | ||
Outdoor temperature sensor Pt 100 | |||
Outdoor temperature sensor Pt 100 | 2533772 | ||
Signal converter retrofit kit | |||
Signal converter 0-10 V / 0-20 mA | 2534992 | ||
DDG impulse selector | |||
DDG impulse selector | 2533770 | ||
Temperature module | |||
Temperature module for systems with 4-6 pumps | 2533771 | ||
Temperature module for systems with 1-3 pumps | 2534991 | ||
Communication module ModBus | |||
Communication module Modbus RTU | 2533869 | ||
SC communication module BACnet | |||
SC-communication module BACnet MS/TP (slave) | 2538242 | ||
BACnet IP SC communication module | 2553366 | ||
Communication module LON (SC) | |||
Communication module LON (SC) | 2538243 | ||
Communication module GSM (SC) | |||
Communication module GSM (SC) | 2542216 | ||
SC-HVAC signal board | |||
SC-HVAC signal board | 2119646 | ||
Output filter EFC (150-500 m cable length) | |||
2.4 A sin IP54 Wilo-EFC filter | 6084559 | ||
2.5 A sin IP00 Wilo-EFC filter | 6084574 | ||
2.5 A sin IP20 Wilo-EFC filter | 6084900 | ||
Pump control/Smart control system (8) | |||
SC/SC-FC-HVAC system | |||
SC-HVAC system 1x1,6A-WM (direct starting) | 2545310 | ||
SC-HVAC system 2x1,6A-WM (direct starting) | 2545311 | ||
SC-HVAC system 3x1,6A-WM (direct starting) | 2545312 | ||
SC-HVAC system 4x1,6A-WM (direct starting) | 2545313 | ||
SC-FC-HVAC system 1x1,6A-FC-WM (direct starting) | 2545426 | ||
SC-FC-HVAC system 2x1,6A-FC-WM (direct starting) | 2545427 | ||
SC-FC-HVAC system 3x1,6A-FC-WM (direct starting) | 2545428 | ||
SC-FC-HVAC system 4x1,6A-FC-WM (direct starting) | 2545429 | ||
Pump control/interface module (6) | |||
IF Modules EFC | |||
Profibus DP MCA Wilo-EFC | 2193451 | ||
DeviceNet MCA Wilo-EFC | 2193452 | ||
Profinet MCA Wilo-EFC | 2193453 | ||
Ethernet/IP MCA Wilo-EFC | 2193454 | ||
Modbus TCP MCA Wilo-EFC | 2193455 | ||
BACnet/IP MCA Wilo-EFC | 5114633 | ||
Differential pressure detection (5) | |||
DDG (4-20mA) | |||
Wilo-DDG 10 Signal Trans.(4-20mA)2G VP. | 2136454 | ||
Wilo-DDG 20 Signal Trans.(4-20mA)2G VP. | 2136456 | ||
Wilo-DDG 40 Signal Trans.(4-20mA)2G VP. | 2136458 | ||
Wilo-DDG 60 Signal Trans.(4-20mA)2G VP. | 2136460 | ||
Wilo-DDG 100 Signal Trans.(4-20mA) | 2211740 | ||
Motor protection (2) | |||
PTC thermistor tripping unit | |||
PTC thermistor tripping unit | 509275993 | ||
Surcharge for thermistor sensor (single pumps) | |||
Surcharge for thermistor sensor <7.5 kW | KLF_7_EP | ||
With Wilo as your partner, you can not only be sure of choosing high-quality product solutions, but also of benefiting from a comprehensive, worry-free package of well thought-out services. We collaborate to develop a service concept tailored to your individual needs; with our expertise and personal consultancy, we make sure that the operation of your systems is as energy-efficient, reliable and economical as possible. All the while our competent Wilo service technicians are ready to assist you with fast, reliable and on-time support.
Read moreExtended Warranty | |||
Extended Warranty Glanded pumps | 2219590 | ||
Supervision | |||
Supervision Glanded pumps | 2219321 | ||
Installation | |||
Installation Glanded pumps | 2219356 | ||
Commissioning | |||
Commissioning Glanded pumps | 2219391 | ||
Maintenance | |||
Maintenance BASIC Glanded pumps | 2219531 | ||
Maintenance COMFORT Glanded pumps | 2219493 | ||
Maintenance PREMIUM Glanded pumps | 2219546 | ||
System Optimisation | |||
System Optimisation Glanded pumps | 2219251 | ||
Energy Solutions | |||
Energy Solutions Glanded pumps | 2219240 | ||
Repairs | |||
Repair Glanded pumps | 2219610 | ||
