Similar to figure
VeroTwin-DPL 50/105-0,75/2-S1
In-line pump
Article number: 2171182
Data sheet
| Hydraulic data | |
|---|---|
| Minimum efficiency index (MEI) | 0.4 |
| Maximum operating pressure PN | 10 bar |
| Min. fluid temperature Tmin | -20 °C |
| Max. fluid temperature Tmax | 120 °C |
| Min. ambient temperature Tmin | -15 °C |
| Max. ambient temperature Tmax | 40 °C |
| Motor data | |
|---|---|
| Mains connection | 3~400 V, 50 Hz |
| Number of poles | 2 |
| Voltage tolerance | ±10 % |
| Motor efficiency class | IE3 |
| Rated power P2 | 0.75 kW |
| Rated current IN | 1.84 A |
| Rated speed n | 2900 1/min |
| Power factor cos φ100 | 0.74 |
| Motor efficiency 50% ηM 50% | 75.4 % |
| Motor efficiency 75% ηM 75% | 79.3 % |
| Motor efficiency 100% ηM 100% | 80.7 % |
| Insulation class | F |
| Protection class motor | IP55 |
| Materials | |
|---|---|
| Pump housing | Grey cast iron |
| Impeller | PPE/PS-GF30 |
| Shaft | Stainless steel |
| Mechanical seal | Q1Q1X4GG |
| Installation dimensions | |
|---|---|
| Pipe connection on the suction side DNs | DN 50 |
| Pipe connection on the discharge side DNd | DN 50 |
| Port-to-port length L0 | 280 mm |
Pump curves
Dimensions and dimensions drawings
VeroTwin-DPL 50/105-0,75/2
Wiring diagram
∆: Connection diagram delta connection
Y: Connection diagram star connection
Motor protection switch required on-site. Check the direction of rotation! To change the direction of rotation, exchange any two phases.
| P2≤ 3 kW | 3~400 V Y |
| 3~230 V ∆ | |
| P2≥ 4 kW | 3~690 V Y |
| 3~400 V ∆ |
After removing the bridges, Y-∆ start is possible.
Acoustics
Airborne sound data sheet
| Airborne sound power LW,A | |
|---|---|
| Octave band centre frequency in Hz | Level in dB(A), ref. 20µPa |
| L63 | 30.5 |
| L125 | 41.4 |
| L250 | 54.3 |
| L500 | 62.6 |
| L1000 | 69.1 |
| L2000 | 69.1 |
| L4000 | 64.9 |
| L8000 | 53.4 |
| Airborne sound-power level (total) Lw | 73 |
| Airborne sound pressure Lp,A,1m | |
|---|---|
| Octave band centre frequency in Hz | Level in dB(A), ref. 1pW |
| L63 | 18.5 |
| L125 | 29.4 |
| L250 | 42.3 |
| L500 | 50.6 |
| L1000 | 57.1 |
| L2000 | 57.1 |
| L4000 | 52.9 |
| L8000 | 41.4 |
| Airborne sound-pressure level (total) Lp | 61 |
The acoustic values given are based on measurements and in some cases on calculations and may deviate by up to 3 dB.
Ordering information
| Product data | |
|---|---|
| Brand | Wilo |
| Product description | VeroTwin-DPL 50/105-0,75/2-S1 |
| Article number | 2171182 |
| EAN number | 4048482705231 |
| Colour | Green |
| Minimum order quantity | 1 |
| Date of sales availability | 2013-03-01 |
| Packaging | |
|---|---|
| Packaging type | Cardboard box |
| Packaging property | Transport packaging |
| Pieces per pallet | 1 |
| Number per layer | 2 |
| Dimension, weight | |
|---|---|
| Length with packaging | 800 mm |
| Length L | 419 mm |
| Height with packaging | 525 mm |
| Height H | 280 mm |
| Width with packaging | 600 mm |
| Width W | 382 mm |
| Gross weight, approx. m | 49 kg |
| Net weight, approx. m | 43 kg |
In-line twin-head pump with two single-stage glanded centrifugal pumps in the same housing with switchover valve in the pressure port. Pump with compact in-line design with directly flanged three-phase current motor and one-piece shafts or with lanterns and standard motors (version N) rigidly connected by couplings.
The DPL series is suitable for pipe installation or installation on a base. Mounting brackets are available as accessories. With force-flushed circulation, bidirectional bellows mechanical seals and cavitation-reducing plastic impeller.
Flanges with pressure measuring connections R 1/8. The pump housing and lantern are cataphoretic-coated.
The motor terminal box can be made of metal or plastic. If a metal terminal box is absolutely necessary, please order the appropriate special variant.
| Operating data | |
|---|---|
| Min. fluid temperature Tmin | -20 °C |
| Max. fluid temperature Tmax | 120 °C |
| Min. ambient temperature Tmin | -15 °C |
| Max. ambient temperature Tmax | 40 °C |
| Maximum operating pressure PN | 10 bar |
| Minimum efficiency index (MEI) | 0.4 |
| Motor data | |
|---|---|
| Motor efficiency class | IE3 |
| Mains connection | 3~400 V, 50 Hz |
| Voltage tolerance | ±10 % |
| Rated power P2 | 750 W |
| Rated speed n | 2900 1/min |
| Rated current IN | 1.84 A |
| Power factor cos φ100 | 0.74 |
| Motor efficiency 50% ηM 50% | 75.4 % |
| Motor efficiency 75% ηM 75% | 79.3 % |
| Motor efficiency 100% ηM 100% | 80.7 % |
| Insulation class | F |
| Protection class | IP55 |
| Materials | |
|---|---|
| Pump housing | Grey cast iron |
| Impeller | PPE/PS-GF30 |
| Shaft | Stainless steel |
| Shaft seal | Q1Q1X4GG |
| Lantern | Grey cast iron |
| Installation dimensions | |
|---|---|
| Pipe connection on the suction side DNs | DN 50 |
| Pipe connection on the discharge side DNd | DN 50 |
| Port-to-port length L0 | 280 mm |
| Ordering information | |
|---|---|
| Brand | Wilo |
| Product description | VeroTwin-DPL 50/105-0,75/2-S1 |
| Net weight, approx. m | 43 kg |
| Article number | 2171182 |
Filtered by
Datasheet and documentation
Installation type
Continuous, infinitely variable control, differential pressure-sensitive SC-HVAC system (25) | |||
Antenna GSM/GPRS | |||
D-network dual-band antenna with 3 m cable | 2533862 | ||
D-network tri-band antenna 10 m cable | 2533863 | ||
D-network tri-band antenna 15 m cable | 2533864 | ||
Outdoor temperature sensor Pt 100 | |||
Outdoor temperature sensor Pt 100 | 2533772 | ||
DDG impulse selector | |||
DDG impulse selector | 2533770 | ||
SC communication module BACnet | |||
SC-communication module BACnet MS/TP (slave) | 2538242 | ||
Communication module LON (SC) | |||
Communication module LON (SC) | 2538243 | ||
Pump signalling module | |||
Signalling module pump 1-2 | 2533812 | ||
Signalling module pump 3-6 | 2533836 | ||
SC-HVAC signal board | |||
SC-HVAC signal board | 2119646 | ||
PTC thermistor tripping unit | |||
PTC thermistor tripping unit | 509275993 | ||
Communication module GSM (SC) | |||
Communication module GSM (SC) | 2542216 | ||
SC/SC-FC-HVAC system | |||
SC-HVAC system 1x2,4A-WM (direct starting) | 2545314 | ||
SC-HVAC system 2x2,4A-WM (direct starting) | 2545315 | ||
SC-HVAC system 3x2,4A-WM (direct starting) | 2545316 | ||
SC-HVAC system 4x2,4A-WM (direct starting) | 2545317 | ||
SC-FC-HVAC system 1x2,4A-FC-WM (direct starting) | 2545430 | ||
SC-FC-HVAC system 2x2,4A-FC-WM (direct starting) | 2545431 | ||
SC-FC-HVAC system 3x2,4A-FC-WM (direct starting) | 2545432 | ||
SC-FC-HVAC system 4x2,4A-FC-WM (direct starting) | 2545433 | ||
DDG (4-20mA) | |||
Wilo-DDG 10 Signal Trans.(4-20mA)2G VP. | 2136454 | ||
Wilo-DDG 20 Signal Trans.(4-20mA)2G VP. | 2136456 | ||
Wilo-DDG 40 Signal Trans.(4-20mA)2G VP. | 2136458 | ||
Wilo-DDG 60 Signal Trans.(4-20mA)2G VP. | 2136460 | ||
Wilo-DDG 100 Signal Trans.(4-20mA) | 2211740 | ||
Continuous, infinitely variable control, temperature-dependent SC-HVAC system (19) | |||
Antenna GSM/GPRS | |||
D-network dual-band antenna with 3 m cable | 2533862 | ||
D-network tri-band antenna 10 m cable | 2533863 | ||
D-network tri-band antenna 15 m cable | 2533864 | ||
Outdoor temperature sensor Pt 100 | |||
Outdoor temperature sensor Pt 100 | 2533772 | ||
SC communication module BACnet | |||
SC-communication module BACnet MS/TP (slave) | 2538242 | ||
Communication module LON (SC) | |||
Communication module LON (SC) | 2538243 | ||
Pump signalling module | |||
Signalling module pump 1-2 | 2533812 | ||
Signalling module pump 3-6 | 2533836 | ||
SC-HVAC signal board | |||
SC-HVAC signal board | 2119646 | ||
PTC thermistor tripping unit | |||
PTC thermistor tripping unit | 509275993 | ||
Communication module GSM (SC) | |||
Communication module GSM (SC) | 2542216 | ||
SC/SC-FC-HVAC system | |||
SC-HVAC system 1x2,4A-WM (direct starting) | 2545314 | ||
SC-HVAC system 2x2,4A-WM (direct starting) | 2545315 | ||
SC-HVAC system 3x2,4A-WM (direct starting) | 2545316 | ||
SC-HVAC system 4x2,4A-WM (direct starting) | 2545317 | ||
SC-FC-HVAC system 1x2,4A-FC-WM (direct starting) | 2545430 | ||
SC-FC-HVAC system 2x2,4A-FC-WM (direct starting) | 2545431 | ||
SC-FC-HVAC system 3x2,4A-FC-WM (direct starting) | 2545432 | ||
SC-FC-HVAC system 4x2,4A-FC-WM (direct starting) | 2545433 | ||
Mechanical accessories
Pipe installation, adapter fitting (5) | |||
Intermediate flange connecting piece F | |||
Intermediate flange pieces F 3, DN 50x20mm, PN 10/16 | 110623190 | ||
Intermediate flange pieces F 5, DN 50x35mm, PN 10/16 | 110623396 | ||
Intermediate flange pieces F 4, DN 50x30mm, PN 10/16 | 110681395 | ||
Intermediate flange pieces F 40, DN 50x160mm, PN 10/16 | 2101156 | ||
Intermediate flange pieces F 2, DN 50x10mm, PN 10/16 | 110791494 | ||
Wall fixation/installation on a base (1) | |||
Mounting bracket kit | |||
Mounting bracket F 3-12 SET | 2040967 | ||
Maintenance/replacement (1) | |||
Blind flanges, glanded pump | |||
Blind flange P154 set | 2023965 | ||
Electrical accessories
Pump control (1) | |||
Wilo-EFC | |||
EFC0.75 3x380-480V 50/60Hz IP55 | 2193431 | ||
Pump control/accessories (25) | |||
Sensor card EFC | |||
Sensor Input Card MCB Wilo-EFC | 6084915 | ||
Communication module CC | |||
CC communication module | 2533850 | ||
Connection cable control modules/signalling modules | |||
Control modules connecting cable | 2533790 | ||
Signalling modules connecting cable | 2533890 | ||
BMS base module | |||
BMS base module | 2533800 | ||
Antenna GSM/GPRS | |||
D-network dual-band antenna with 3 m cable | 2533862 | ||
D-network tri-band antenna 10 m cable | 2533863 | ||
D-network tri-band antenna 15 m cable | 2533864 | ||
SMA/FME adapter | 2545548 | ||
Pump signalling module | |||
Signalling module pump 1-2 | 2533812 | ||
Signalling module pump 3-6 | 2533836 | ||
Outdoor temperature sensor Pt 100 | |||
Outdoor temperature sensor Pt 100 | 2533772 | ||
Signal converter retrofit kit | |||
Signal converter 0-10 V / 0-20 mA | 2534992 | ||
DDG impulse selector | |||
DDG impulse selector | 2533770 | ||
Temperature module | |||
Temperature module for systems with 4-6 pumps | 2533771 | ||
Temperature module for systems with 1-3 pumps | 2534991 | ||
Communication module ModBus | |||
Communication module Modbus RTU | 2533869 | ||
SC communication module BACnet | |||
SC-communication module BACnet MS/TP (slave) | 2538242 | ||
BACnet IP SC communication module | 2553366 | ||
Communication module LON (SC) | |||
Communication module LON (SC) | 2538243 | ||
Communication module GSM (SC) | |||
Communication module GSM (SC) | 2542216 | ||
SC-HVAC signal board | |||
SC-HVAC signal board | 2119646 | ||
Output filter EFC (150-500 m cable length) | |||
2.4 A sin IP54 Wilo-EFC filter | 6084559 | ||
2.5 A sin IP00 Wilo-EFC filter | 6084574 | ||
2.5 A sin IP20 Wilo-EFC filter | 6084900 | ||
Pump control/Smart control system (8) | |||
SC/SC-FC-HVAC system | |||
SC-HVAC system 1x2,4A-WM (direct starting) | 2545314 | ||
SC-HVAC system 2x2,4A-WM (direct starting) | 2545315 | ||
SC-HVAC system 3x2,4A-WM (direct starting) | 2545316 | ||
SC-HVAC system 4x2,4A-WM (direct starting) | 2545317 | ||
SC-FC-HVAC system 1x2,4A-FC-WM (direct starting) | 2545430 | ||
SC-FC-HVAC system 2x2,4A-FC-WM (direct starting) | 2545431 | ||
SC-FC-HVAC system 3x2,4A-FC-WM (direct starting) | 2545432 | ||
SC-FC-HVAC system 4x2,4A-FC-WM (direct starting) | 2545433 | ||
Pump control/interface module (5) | |||
IF Modules EFC | |||
Profibus DP MCA Wilo-EFC | 2193451 | ||
DeviceNet MCA Wilo-EFC | 2193452 | ||
Profinet MCA Wilo-EFC | 2193453 | ||
Ethernet/IP MCA Wilo-EFC | 2193454 | ||
Modbus TCP MCA Wilo-EFC | 2193455 | ||
Differential pressure detection (5) | |||
DDG (4-20mA) | |||
Wilo-DDG 10 Signal Trans.(4-20mA)2G VP. | 2136454 | ||
Wilo-DDG 20 Signal Trans.(4-20mA)2G VP. | 2136456 | ||
Wilo-DDG 40 Signal Trans.(4-20mA)2G VP. | 2136458 | ||
Wilo-DDG 60 Signal Trans.(4-20mA)2G VP. | 2136460 | ||
Wilo-DDG 100 Signal Trans.(4-20mA) | 2211740 | ||
Motor protection (2) | |||
PTC thermistor tripping unit | |||
PTC thermistor tripping unit | 509275993 | ||
Surcharge for thermistor sensor (dual pumps) | |||
Surcharge for thermistor sensor (dual pumps) <7.5 kW | KLF_7_DP | ||
With Wilo as your partner, you can not only be sure of choosing high-quality product solutions, but also of benefiting from a comprehensive, worry-free package of well thought-out services. We collaborate to develop a service concept tailored to your individual needs; with our expertise and personal consultancy, we make sure that the operation of your systems is as energy-efficient, reliable and economical as possible. All the while our competent Wilo service technicians are ready to assist you with fast, reliable and on-time support.
Read moreExtended Warranty | |||
Extended Warranty Glanded pumps | 2219590 | ||
Supervision | |||
Supervision Glanded pumps | 2219321 | ||
Installation | |||
Installation Glanded pumps | 2219356 | ||
Commissioning | |||
Commissioning Glanded pumps | 2219391 | ||
Maintenance | |||
Maintenance BASIC Glanded pumps | 2219531 | ||
Maintenance COMFORT Glanded pumps | 2219493 | ||
Maintenance PREMIUM Glanded pumps | 2219546 | ||
System Optimisation | |||
System Optimisation Glanded pumps | 2219251 | ||
Energy Solutions | |||
Energy Solutions Glanded pumps | 2219240 | ||
Repairs | |||
Repair Glanded pumps | 2219610 | ||
